Optimization of Nitrogen, Phosphorus, and Farmyard Manure Fertilizers Application Rates in Fodder Maize Production by Response Surface Methodology

Document Type : Research Article

Authors

• A. R Nokhbehzaeim ¹
• M Jahan ²
• A Beheshti ³

¹ PhD. Student of Agroecology, Department of Agrotechnology, Faculty of Agriculture, Ferdowsi University of Mashhad, Mashhad, Iran

² Department of Agrotechnology, Faculty of Agriculture, Ferdowsi University of Mashhad, Mashhad, Iran

³ Agricultural and Natural Resources Research and Education Center of Khorasan-e Razavi, Agricultural- Research-Education & Extension Organization (AREEO), Mashhad, Iran

10.22067/jcesc.2023.82946.1254

Abstract

Introduction
The excessive use of chemical fertilizers is a leading cause of environmental pollution in the agriculture sector. Therefore, optimizing fertilizer application is a crucial approach to boost production while minimizing environmental harm. On the other hand, application of chemical fertilizers along with manure can be considered as the proper management system that led to reduce the amount of chemical fertilizers and adverse effects on environment and also improve nutrition for plants. Response-surface methodology is a powerful tool to optimize production resources which decreases cost and time of the experiments by reducing number of them. Therefore, the aim of the study was optimization of chemical fertilizers of nitrogen and phosphorus along with manure application in fodder maize production.
Materials and Methods
The field experiment was carried out according to box-benkhen design in Savojbelagh, where located in the west of Alborz province, over two years 2017 and 2018. The fifteen treatments were selected based on low and high levels of nitrogen (0 and 300 kg.ha^-1), phosphorus (0 and 150 kg.ha^-1), and manure (0 and 40 ton.ha^-1). Three replications were considered in central points under box-benkhen design. The experiment was performed in two replications. Fodder yield, dry matter, nitrogen losses, and nitrogen use efficiency were the measured traits in the study. Stepwise regression model by fitting a full quadratic function were used to predict response variables. Treatments were optimized based on three scenarios: economic, environmental, and eco-environmental. Fodder yield, nitrogen losses, and nitrogen use efficiency were the primary factors used to determine the treatments in each respective scenario. In final, the optimum levels of treatments as independent variables were suggested to obtain target amounts of traits as dependent variables in each scenario. All analysis was performed using Minitab ver.16.
Results and Discussion
The results of regression analysis showed that the model had adequate accuracy to predict the studied properties (as dependent variables) based on experimental treatments (as independent variables). The calculated values of NRMSE illustrated that the model predicted data of dry matter, fodder yield, nitrogen losses, and nitrogen use efficiency with difference as 5.4, 2.3, 6.1, and 17.4 percent from measured data, respectively. Fodder yield was raised by increasing nitrogen fertilizer under all levels of phosphorus and manure. Increase slope of fodder yield by increasing nitrogen fertilizer amount under high levels of phosphor and manure was more than in low levels. The highest nitrogen loss was gained by application of 300 kg N.ha^-1 along with no application of manure under nitrogen fertilizer × manure interaction. As findings, increasing the amount of nitrogen fertilizer caused to increase nitrogen losses and decrease in nitrogen use efficiency. Application of 242.42 kg N.ha^-1 and 95.45 kg P.ha^-1 along with 33.13 t manure.ha^-1 was suggested under economic scenario that led to produce 105 t fodder.ha^-1 with nitrogen losses of 150 kg.ha^-1. In environmental scenario, no application of nitrogen and using 146.9 kg P.ha^-1 with 21.82 t manure. ha^-1 was proposed to gain 80.94 t fodder and 51.2 kg. ha^-1 as nitrogen losses and 103.03 kg fodder.kg^-1 N as nitrogen use efficiency. Under eco-environmental scenario that had priority in comparison with two other scenarios due to considering economical and environmental issues simultaneously; applying 78.79 kg N.ha^-1, 150 kg P.ha^-1and 8.48 t manure.ha^-1 was suggested as optimum levels of treatments that led to obtain 90.87 t fodder.ha^-1, 64.75 kg N losses.ha^-1 and the highest value of nitrogen use efficiency as 116.4 kg fodder.ha^-1 N.
Conclusion
Considering the results, applying 78.79 kg N.ha^-1, 150 kg P.ha^-1and 8.48 t manure.ha^-1 in eco-environmental scenario was suggested as optimum levels of treatments.

Keywords

• Chemical fertilizers
• Environmental scenario
• Nitrogen losses
• Optimum values

20.1001.1.20081472.1402.21.4.6.8

Main Subjects

• Plant modeling

---

©2024 The author(s). This article is licensed under Creative Commons Attribution 4.0 International License (CC BY 4.0), which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source.

References

Adesemoye, A. O., Torbert, H. A., & Klopper, J. W. (2009). Plant growth promoting rhizobacteria allow reduced application rates of chemical fertilizers. Microbial Ecology, 58, 921-929. https://doi.org/10.1007/s00248-009-9531-y

Akintoye, H. A., Klinga, J. G., & Lucas, E. O. (1999). N-use efficiency of single, double and synthetic maize lines grown at four N levels in three ecological zones of West Africa. Field Crops Research, 60, 189-199. https://doi.org/10.1016/s0378-4290(98)00122-1

Alexandratos, N., & Bruinsma, J. (2012). World agriculture towards 2030/2050: the 2012 revision. Global Perspective Studies Team, FAO Agricultural Development Economics Division.

Amiri, M.B., Jahan, M., & Rezvani-Moghaddam, P. (2022). An exploratory methodto determine the plant characteristics affecting the final yield of Echium amoenum Fisch. & C.A. Mey. under fertilizers application and plant densities. Scientific Reports, 12:1881. https://doi.org/10.1038/s41598-022-05724-8

Christianson, L. E., & Harmel, R. D. (2015). 4R water quality impacts: an assessment and synthesis of forty years of drainage nitrogen losses. Journal of Environmental Quality, 44, 1852-1860. https://doi.org/10.2134/jeq2015.03.0170

Cojocaru, C., & Zakrzewska-Trznadel, G. (2007). Response surface modeling and optimization of copper removal from aqua solutions using polymer assisted ultrafiltration. Journal of Membrane Science, 298, 56-70. https://doi.org/10.1016/j.memsci.2007.04.001

David, M. B., Drinkwater, L. E., & Mclsaac, G. F. (2010). Sources of nitrate yields in the Mississippi River basin. Journal of Environmental Quality, 39, 1657-1667. https://doi.org/10.2134/jeq2010.0115

Doberman, A., & Cassman, K. G. (2005). Cereal area, yield and nitrogen use efficiency are drives for future nitrogen fertilizer consumption. Science in China, 48, 745-758. https://doi.org/10.1007/BF03187115

Emdad, M. R., Tafteh, A., & Ghaffari Nejad, S. A. (2023). Effect of using organic fertilizer on the changes of soil physical properties in different rotations cultivation in permanent plots. Water and Soil Management and Modeling, Accepted Manuscript Available Online from 08 April 2023. (in Persian with English abstract). https://doi.org/10.22098/mmws.2023.12491.1245

Fageria, N. K. (2014). Nitrogen Management in Crop Production. New York: CRC Press. ISBN: 978-1-4822-2283-8.

FAO. (2022). FAOSTAT. Land, Inputs and Sustainability. Available at: https://www.fao.org/faostat/en/#data/RFN

Gastal, F., & Lemaire, G. (2002). N uptake and distribution in crops: an agronomical and ecophysiological perspective. Journal of Experimental Botany, 53(370), 789-799. https://doi.org/10.1093/jexbot/53.370.789

Greer, K. D., & Pittelkow, C. M. (2018). Linking Nitrogen Losses With Crop Productivity in Maize Agroecosystems. Frontiers in Sustainable Food Systems, 2(29), 1-9. https://doi.org/10.3389/fsufs.2018.00029

Halvorson, A. D., Bartolo, M. E., Reule, C. A., & Berrada, A. (2008). Nitrogen effects on onion yield under drip and furrow irrigation. Agronomy Journal, 100(4), 1062-1069. https://doi.org/10.2134/agronj2007.0377

Hawkesford, M. J., & Barraclough, P. (2011). The Basis of Nutrient Use Efficiency in Crops. WILEYBLACKWELL, USA. ISBN: 978-0-8138-1992-1.

Helmers, M. J., Zhou, X., Baker, J. L., Melvin, S. W., & Lemke, D. W. (2012). Nitrogen loss on tile drained Mollisols as affected by nitrogen application rate under continuous corn and corn-soybean rotations. Canadian Journal of Soil Science, 92, 493-499. https://doi.org/10.4141/cjss2010-043

Jafari Malekabadi, A., Afyuni, M., Mousavi, S. F., & Khosravi, A. (2004). Nitrate concentration in groundwater in Isfahan province. Journal of Water and Soil Science, 8(3), 69-83. (In Persian with English abstract). https://doi.org/20.1001.1.24763594.1383.8.3.6.1

Jahan, M., Nassiri Mahallati, M., Khalilzade, H., Bigonah, R., & Razavi, A. R. (2016). Optimizing of Nitrogen, Phosphorus and Cattle Manure Fertilizers Application in Winter Wheat Production Using Response-Surface Methodology (RSM). Iranian Journal of Field Crops Research, 13(4), 823-839. (In Persian with English abstract). https://doi.org/10.22067/gsc.v13i4.39788

Jahan, M., & Amiri, M.B. (2018). Optimizing application rate of nitrogen, phosphorus and cattle manure in wheat production: An approach to determine optimum scenario using response-surface methodology. Journal of Soil Science and Plant Nutrition, 18(1), 13-26. https://doi.org/10.4067/S0718-95162018005000102

Jarvis, S., Hutchings, N., Brentrup, F., Olesen, J. E., & Van Der Hock, K. W. (2011). Nitrogen flows in farming systems across Europe. In: The European Nitrogen Assessment: source, effects and policy perspectives. Sutton, M.A., Howard, C. M., Erisman, J. W., Billen, G., Bleeker, G., Grennfelt, A., Grinsven, H. V., & Grizzetti, B. (2011). Cambridge University Press. Part III, Chapter 10.

Jaynes, D. B., Colvin, T. S., Karlen, D. L., Cambardella, C. A., & Meek, D. W. (2001). Nitrate loss in subsurface drainage as affected by nitrogen fertilizer rate Journal of Environmental Quality, 30, 1305-1314. https://doi.org/10.2134/jeq2001.3041305x

Kalavathy, H. M., Regupathib, I., Pillai, M. G., & Miranda, L. R. (2009). Modelling, analysis and optimization of adsorption parameters for H₃PO₄ activated rubber wood sawdust using response surface methodology (RSM). Colloids and Surfaces B: Biointerfaces, 70, 35-45. https://doi.org/10.1016/j.colsurfb.2008.12.007

Karmoker, J. R., Hasan, I., Ahmed, N., Saifuddin, M., & Reza, M. S. (2019). Development and Optimization of Acyclovir Loaded Mucoadhesive Microspheres by Box -Behnken Design. Dhaka University Journal of Pharmaceutical Sciences, 18(1), 1-12. https://doi.org/10.3329/dujps.v18i1.41421

Khodshenas, M. A., Ghadbeiklou, J., & Dadivar, M. (2016). The Effects of Source and Rate of Nitrogen Fertilizer and Irrigation on Nitrogen Uptake of Silage Corn and Residual Soil Nitrate. Journal of Water and Soil, 29(6), 1640-1650. (in Persian with English abstract). https://doi.org/10.22067/jsw.v29i6.35254

Kim, H. J., & Li, X. (2016). Effects of Phosphorus on Shoot and Root Growth, Partitioning, and Phosphorus Utilization Efficiency in Lantana. Hortscience, 51(8), 1001-1009. https://doi.org/10.21273/hortsci.51.8.1001

Koocheki, A., Nassiri Mahallati, M., Moradi, A., & Mansouri, H. (2013). Optimization of water, nitrogen and density in canola cultivation by central composite design. Journal of Agroecology, 3(1), 1-16. (in Persian with English abstract).

Lawlor, P. A., Helmers, M. J., Baker, J. L., Melvin, S. W., & Lemke, D. W. (2008). Nitrogen application rate effect on nitrate-N concentration and loss in subsurface drainage for a corn-soybean rotation. Trans. ASABE, 51, 83-94. https://doi.org/10.13031/2013.24229

Mansouri, H., Bannayan, M., Rezvani Moghaddam, P., & Lakzian, A. (2014). Management of nitrogen fertilizer, irrigation and plant density in onion production using response surface methodology as optimization approach. African Journal of Agricultural Researc, 9(7), 676-687. https://doi.org/10.5897/ajar2013.8428

Marino, M. A., Mazzanti, A., Assuero, S. G., Gastal, F., Echeverria, H. E., & Andrade, F. (2004). Nitrogen dilution curves and nitrogen use efficiency during winter-spring growth of annual ryegrass. Agronomy Journal, 96, 601-607. https://doi.org/10.2134/agronj2004.0601

Mirzashahi, K., & Hossainpour, M. (2014). The effect of nitrogen fertilization management on grain yield and nitrogen efficiency indices in corn. Agronomy Journal (Pajouhesh & Sazandegi), 102, 31-40. (In Persian with English abstract). https://doi.org/10.22092/aj.2014.100926

Mohiti Asl, A. (2011). Effect of cow manure, biological and chemical fertilizers on some physic-chemical properties of soil and yield of forage corn in Amiran of Damgha. MSc thesis. Shahrood university. 139 p. (in Persian with English abstract).

Moraghebi, F., Akbari Famileh, M., & Houshmandfar, A. (2012). The effect of amount and time of Nitrogen use on the percentage of grain protein and efficiency use of Nitrogen of the Pishtaz cultivar wheat in Saveh region. Plant and Ecosystem, 7(29), 65. (in Persian with English abstract).

Myers, R. H., & Montgomery, D. C. (1995). Response surface methodology: process and product optimization using designed experiments. John Willey & Sons, New York, USA.

Nelson, D. W., & Somers, L. E. (1973). Determination of total nitrogen in plant material. Agronomy Journal, 65, 109-112. https://doi.org/10.2134/agronj1973.00021962006500010033x

Rathke, G. W., Behrens, T., & Diepenbrock, W. (2006). Integrated nitrogen management strategies to improve seed yield, oil content and nitrogen efficiency of winter oilseed rape (Brassica napus L.): A review. Agriculture, Ecosystems and Environment, 117, 80-108. https://doi.org/10.1016/j.agee.2006.04.006

Sadat-Rozati, N. (2008). The evaluation of the effect of consumption management of urea fertilizer on yield and component of yield in three cultivar of maize. MSc thesis. Shahrood University of Technology. (In Persian with English abstract).

Torbert, H. A., Potter, K. N., & Morrison, J. E. (2001). Tillage system, fertilizer nitrogen rate and timing effect on corn yields in the Texas Blackland prairie. Agronomy Journal, 93, 1119-1124. https://doi.org/10.2134/agronj2001.9351119x

Weligama, C., Sale, P. W. G., Conyers, M. K., Liu, D. L., & Tang, C. (2010). Nitrate leaching stimulates subsurface root growth of wheat and increase rhizosphere alkalization in a highly acidic soil. Plant and Soil, 328, 119-132. https://doi.org/10.1007/s11104-009-0087-x

Zhou, M., & Butterbach-Bahl, K. (2014). Assessment of nitrate leaching loss on a yield-scaled basis from maize and wheat cropping systems. Plant Soil, 374, 977-991. https://doi.org/10.1007/s11104-013-1876-9